Fish meal QG Series Air Dryer Equipment
Basic Info
Model No.: QG, JG, FG
Product Description
Working principle:
The wet material enters the dryer at the same time through the conveyer and the heated natural air, and the two are fully mixed. Because of the large area of heat and mass exchange, the purpose of evaporation and drying is achieved in a very short time. After drying, the finished product is discharged from the cyclone separator, and a small part of the fly powder is recovered from the cyclone dust collector or the bag dust collector. The type Q air flow dryer is a negative pressure operation, and the material does not pass through the fan QG type air flow dryer is a positive pressure operation. The FG type airflow dryer is a type of exhaust circulation type.
Fan with dispersion, especially suitable for air drying of heat sensitive materials. The fan impeller with high speed spin can break up the wet or even caking material until it is dispersed, stir and mix simultaneously in the process of dispersion, and then flow in parallel with the hot air flow. This type of equipment, suitable for drying filter block, but also belong to surface moisture, moisture content ≤ 40, if the treatment capacity or the finished product required to dry below 15%, can be used for secondary air drying. When the moisture content of the material exceeds 40 parts.
However, when the feed is less than 60, it is difficult to feed, so the mixer should be used to reduce the feed water content by mixing dry material. At this time, the total output of the drying equipment will decrease by a large margin, which is not reasonable in economic terms. Therefore, the user should first use mechanical methods (centrifugal dehydration or pressure filtration) to minimize the intake of water to ensure the smooth operation of drying.
QG series pulse air dryer is a large batch of drying equipment. It adopts the principle of instantaneous drying. It uses the rapid movement of hot air to drive the wet material and suspends the wet material in the hot air. This strengthens the whole drying process and improves The rate of heat and mass transfer, the material dried by the airflow, the non-bonded moisture can be almost completely removed (for example, the moisture content of starch and other materials is less than or equal to 40%, the finished material can be 13.5%), and the dried material No deterioration will occur, and the output can be significantly improved compared to the drying of general dryers. Users can achieve higher economic benefits in the short term.
Product Features
QG air dryer is suitable for drying and dehumidifying powdery materials in the pharmaceutical, chemical, food, building materials, plastic and other industries. For example: starch, Fish Meal, salt, distiller's grains, feed, gluten, plastic resin, mineral powder, pulverized coal , Chloronic acid, A · S · C simple butyric acid, 2 · 3 · acid, polychloroacetic acid polypropylene, sodium sulfate, sodium metabisulfite and other materials drying.
Our company consulted with the air drying equipment and designed and manufactured the non-fixed air dryer.
Technical specifications
Specifications | QG-50 | QG-100 | QG-250 | QG-500 | QG-1500 | |
Moisture evaporation | Kg/h | 50 | 100 | 250 | 500 | 1500 |
air filter | Area (m2) | 4 | 6 | 18 | 36 | 60 |
Number of stations | 1 | 1 | 1 | 2 | 2 | |
Replacement time (h) | 200 (filter bag) | 200 (filter bag) | 200 (filter bag) | 200 (filter bag) | 200 (filter bag) | |
Heater | Area (m2) | 30 | 43 | 186 | 365 | 940 |
Steam consumption (kg) | 120 | 235 | 450 | 972 | 2430 | |
Working pressure (Mpa) | 0.6-0.8 | 0.6-0.8 | 0.6-0.8 | 0.6-0.8 | 0.6-0.8 | |
Fan | model | 9-19-4.5 | 9-26-4.5 | 9-19-9 | 9-19-9 | 9-26-6.3 |
Number of stations | 1 | 1 | 1 | 2 | 4 | |
Power (kw) | 7.5 | 11 | 18.5 | 37 | 125 | |
Feeder | Delivery volume (kg/h) | 150 | 290 | 725 | 1740 | 4350 |
control method | Electromagnetic speed regulating motor | Electromagnetic speed regulating motor | Electromagnetic speed regulating motor | Electromagnetic speed regulating motor | Electromagnetic speed regulating motor | |
Power (kw) | 0.6 | 1.1 | 3 | 3 | 7.5 | |
Cyclone separator | model | CLK-350-400 | CLK-500-450 | ZF12.5 | ZF12.5 | |
effectiveness(%) | 98 | 98 | 98 | 98 | ||
Quantity | 2 | 2 | 2 | 3 | ||
Bag filter | Quantity | 1 | 1 | 1 | 1 | 1 |
Water Consumption | 3.6-20.0 |
JG series air dryer
working principle
JG series air dryer from readily dehydrated particles, powder materials, the rapid removal of water (mostly the water surface). In air drying, the quality of the dried product is best controlled due to the short residence time of the material in the dryer. The enhanced airflow drying of our factory is based on the addition of a set of fortifiers capable of stepless speed adjustment on the basic model. The wet material is mixed with the hot air flow after entering the fortifier through the screw feeder, and is crushed and propelled by the rapidly rotating knife. Next, the material is broken into fine particles, which moves toward the outlet while drying, and finally enters the drying tube under the suction of the wind, and is further evenly dried. Wet and heavy particles that cannot be attracted by wind continue to be crushed and dried until they can be sucked into the drying tube by the wind.
The main purpose
The machine is especially suitable for materials with large moisture content, wet material is paste-like, can not be dried by other air drying methods, such as: white carbon black, copolymer of vinyl acetate and vinyl chloride, cellulose acetate fiber, catalyst , CMC, CT-1 resin, forging gypsum, electrolytic manganese dioxide, ammonium sulfonium sulfonate, fluorspar, diatomaceous earth, silica gel catalyst, bone powder, high territories, potassium perchlorate sulfonamide, synthetic resin, active gluten , activated clay, chemical filter cake, rutile type white powder, sebacic acid, copper sulfate, aluminum sulfate, sodium sulfate, Calcium Phosphate, phosphate esterified starch, dyes, calcium citrate, slime, dough-shaped bread filling rice bran , clay, clay cement, urea, bentonite, spherical clay, aluminum hydroxide, barium hydroxide, calcium lactate, food, washed highland, cyanuric acid, gypsum paddles, lime, biological products, carbon black, calcium carbonate slurry, Sludge sludge, organic chemicals, aluminum stearate, iron oxide, organic fuels, corn protein feed, wet mud, mica powder, pharmaceuticals, pigments, potassium dichromate pulp, distiller's grains, etc.
Technical specifications
model | Evaporation moisture kg/h (calculated by surface moisture) | Installed power kw | Land area m 2 | Height m |
JG 50 | 50 | 10 | 20 | 9 |
JG 100 | 100 | 20 | 32 | 11 |
JG 200* | 200 | 31 | 40 | 11 |
JG 250 | 250 | 32 | 64 | 13 |
JG 500* | 500 | 54 | 96 | 13 |
JG 1000* | 1,000 | 135 | 120 | 15 |
JG 1500* | 1500 | 175 | 200 | 16 |
Note: Those with * are secondary drying, installed power, and the area is calculated by steam heating. |
FG series air dryer
working principle
The working principle of the FG series airflow dryer is to complete the drying of the wet material in two steps. The raw materials are firstly subjected to positive pressure drying by a mixture of secondary drying tail gas and supplementary hot air, and the used high temperature and low humidity tail gas is discharged outside the machine. The dried semi-finished products are dried by fresh hot air and subjected to secondary negative pressure. Dry finished measuring packaging. The used high-temperature and low-humidity exhaust gas is used as a first-stage drying to complete a good cycle drying process. The amount of supplemental hot air can be arbitrarily adjusted as required, so that the machine has wide applicability.
Adaptable Materials
This equipment is widely used for the drying of powdery and granular materials in the food, chemical, pharmaceutical, building materials and other industries. The products that have been used in this series are: starch, glucose, fish powder, sugar, sugar, wine trough, feed, gluten, plastic resin, coal powder, dyes, etc.
Technical specifications
model | Evaporation moisture (kg/h) | Installed power kw | Land area m 2 | Thermal efficiency(%) |
FG0.25 | 113 | 11 | 3.5x2.5 | >60 |
FG0.5 | 225 | 18.5 | 7x5 | >60 |
FG0.9 | 450 | 30 | 7x6.5 | >60 |
FG1.5 | 675 | 50 | 8x7 | >60 |
FG2.0 | 900 | 75 | 11x7 | >60 |
FG2.5 | 1125 | 90 | 12x8 | >60 |
FG3.0 | 1150 | 110 | 14x10 | >60 |
FG3.5 | 1491 | 110 | 14x10 | >60 |
Contact us if you need more details on Fish Meal Air Dryer Equipment. We are ready to answer your questions on packaging, logistics, certification or any other aspects about Fish Meal Air Dryer Machine、Fish Meal Hot Air Dryer Equipment. If these products fail to match your need, please contact us and we would like to provide relevant information.
Product Categories : Drying Series > Other Dryer Machine